Detection and Quantification of Mono-Rhamnolipids and Di-Rhamnolipids Produced by Pseudomonas aeruginosa.

The environmental bacterium Pseudomonas aeruginosa is an opportunistic pathogen with high antibiotic resistance that represents a health hazard. This bacterium produces high levels of biosurfactants known as rhamnolipids (RL), which are molecules with significant biotechnological value but are also associated with virulence traits. In this respect, the detection and quantification of RL may be useful for both biotechnology applications and biomedical research projects. In this article, we demonstrate step-by-step the technique to detect the production of the two forms of RL produced by P. aeruginosa using thin-layer chromatography (TLC): mono-rhamnolipids (mRL), molecules constituted by a dimer of fatty acids (mainly C10-C10) linked to one rhamnose moiety, and di-rhamnolipids (dRL), molecules constituted by a similar fatty acid dimer linked to two rhamnose moieties. Additionally, we present a method to measure the total amount of RL based on the acid hydrolysis of these biosurfactants extracted from a P. aeruginosa culture supernatant and the subsequent detection of the concentration of rhamnose that reacts with orcinol. The combination of both techniques can be used to estimate the approximate concentration of mRL and dRL produced by a specific strain, as exemplified here with the type strains PAO1 (phylogroup 1), PA14 (phylogroup 2), and PA7 (phylogroup 3).

Biodegradable poly(ethylene glycol-glycerol-itaconate-sebacate) copolyester elastomer with significantly reinforced mechanical properties by in-situ construction of bacterial cellulose interpenetrating network.

To address the concern that biodegradable elastomers are environmental-friendly but usually associated with poor properties for practical utilization, we report a star-crosslinked poly(ethylene glycol-glycerol-itaconate-sebacate) (PEGIS) elastomer synthesized by esterification, polycondensation and UV curing, and reinforced by bacterial cellulose (BC). The interpenetrating network of primary BC backbone and vulcanized elastomer is achieved by the "in-situ secondary network construction" strategy. With the well dispersion of BC without agglomeration, the mechanical properties of PEGIS are significantly enhanced in tensile strength, Young's modulus and elongation at break. The reinforcement strategy is demonstrated to be efficient and offers a route to the development of biodegradable elastomers for a variety of applications in the future.

High mono-rhamnolipids production by a novel isolate Pseudomonas aeruginosa LP20 from oily sludge: characterization, optimization, and potential application.

This study aims to isolate microbial strains for producing mono-rhamnolipids with high proportion. Oily sludge is rich in petroleum and contains diverse biosurfactant-producing strains. A biosurfactant-producing strain LP20 was isolated from oily sludge, identified as Pseudomonas aeruginosa based on phylogenetic analysis of 16S rRNA. High-performance liquid chromatography-mass spectrometry results indicated that biosurfactants produced from LP20 were rhamnolipids, mainly containing Rha-C8-C10, Rha-C10-C10, Rha-Rha-C8-C10, Rha-Rha-C10-C10, Rha-C10-C12:1, and Rha-C10-C12. Interestingly, more mono-rhamnolipids were produced by strain LP20 with a relative abundance of 64.5%. Pseudomonas aeruginosa LP20 optimally produced rhamnolipids at a pH of 7.0 and a salinity of 0.1% using glycerol and nitrate. The culture medium for rhamnolipids by strain LP20 was optimized by response surface methodology. LP20 produced rhamnolipids up to 6.9 g L-1, increased by 116%. Rhamnolipids produced from LP20 decreased the water surface tension to 28.1 mN m-1 with a critical micelle concentration of 60 mg L-1. The produced rhamnolipids emulsified many hydrocarbons with EI24 values higher than 56% and showed antimicrobial activity against Staphylococcus aureus and Cladosporium sp. with inhibition rates 48.5% and 17.9%, respectively. Pseudomonas aeruginosa LP20 produced more proportion of mono-rhamnolipids, and the LP20 rhamnolipids exhibited favorable activities and promising potential in microbial-enhanced oil recovery, bioremediation, and agricultural biocontrol.

Solvent-free synthesis of hydrophobic and amphiphilic esters using a chemically modified lipase from Thermomyces lanuginosus: a comparative study with native and immobilized forms.

Using lipases to catalyze the synthesis of the most differentiated type of compounds remains one of the major challenges among scientists. Seeking more economic and advantageous catalysts is a current goal of green chemistry. In this work, we demonstrate the potential of a chemically modified form of lipase from Thermomyces lanuginosus (cmLTL) for the synthesis of both hydrophobic (heptyl heptanoate, heptyl octanoate, heptyl decanoate, decyl heptanoate, decyl octanoate and decyl decanoate) and amphiphilic (2-(2-ethoxyethoxy)ethyl oleate and 2-(2-ethoxyethoxy)ethyl linoleate) esters, in bulk. The results were compared with its native (LTL) and immobilized (imLTL) forms. The data revealed that LTL showed poor activity for all reactions performed with n-heptane (η<20 %). ImLTL was able to synthesize all hydrophobic esters (η>60 %), with exception of the short ester, heptyl heptanoate. cmLTL was the only form of LTL capable of producing hydrophobic and amphiphilic esters, without compromising the yield when the reactions were performed under solvent-free conditions (>50 %). Molecular modeling showed that the active pocket of cmLTL is able to deeply internalize transcutol, with stronger interactions, justifying the outstanding results obtained. Furthermore, owing to the possibility of cmLTL filtration, the reusability of the catalyst is ensured for at least 6 cycles, without compromising the reaction yields.

Bivalent mRNA vaccines against three SARS-CoV-2 variants mediated by new ionizable lipid nanoparticles.

Lipid nanoparticles (LNPs)-based mRNA vaccines have shown great potential in the fight against the severe acute respiratory syndrome coronavirus 2 (SARS-CoV-2) pandemic. However, it remains still a challenge to improve the delivery efficiency of LNPs and the long-term stability of their mediated mRNA vaccines. Herein, a novel ionizable lipid 2-hexyldecyl 6-(ethyl(3-((2-hexyldecyl)oxy)-2-hydroxypropyl)amino)hexanoate (HEAH) derived LNPs were developed for delivering the receptor binding domain (RBD) mRNAs. In vitro cell assays confirmed that the ionizable lipid HEAH with one ether bond and one ester bond derived LNPs possessed higher mRNA delivery efficiency compared with the approved ALC-0315 with two ester bonds used in the BNT162b2 vaccine. Notably, the HEAH-derived LNPs powder lyophilized did not significantly change for 30 days after storage at 37 °C indicating good thermostability. After two RBD mRNAs of Delta and Omicron variants were encapsulated into the HEAH-derived LNPs, a bivalent mRNA vaccine was obtained as a nanoparticle formulation. Importantly, the bivalent mRNA vaccine not only resisted Delta and Omicron and also generated protective antibodies against ancestral SARS-CoV-2. The HEAH-mediated bivalent vaccine induced stronger humoral and cellular immunity than those of the ALC-0315 group. Taken together, the ionizable lipid HEAH-derived LNPs show outstanding potential in improving the delivery efficiency of mRNA and the stability of mRNA vaccine.

Bioconversion and P-gp-Mediated Transport of Depot Fluphenazine Prodrugs after Intramuscular Injection.

Fluphenazine (FPZ) decanoate, an ester-type prodrug formulated as a long-acting injection (LAI), is used in the treatment of schizophrenia. FPZ enanthate was also developed as an LAI formulation, but is no longer in use clinically because of the short elimination half-life of FPZ, the parent drug, after intramuscular injection. In the present study, the hydrolysis of FPZ prodrugs was evaluated in human plasma and liver to clarify the reason for this difference in elimination half-lives. FPZ prodrugs were hydrolyzed in human plasma and liver microsomes. The rate of hydrolysis of FPZ enanthate in human plasma and liver microsomes was 15-fold and 6-fold, respectively, faster than that of FPZ decanoate. Butyrylcholinesterase (BChE) and human serum albumin (HSA) present in human plasma, and two carboxylesterase (CES) isozymes, hCE1 and hCE2, expressed in ubiquitous organs including liver, were mainly responsible for the hydrolysis of FPZ prodrugs. FPZ prodrugs may not be bioconverted in human skeletal muscle at the injection site because of lack of expression of BChE and CESs in muscle. Interestingly, although FPZ was a poor substrate for human P-glycoprotein, FPZ caproate was a good substrate. In conclusion, it is suggested that the shorter elimination half-life of FPZ following administration of FPZ enanthate compared with FPZ decanoate can be attributed to the more rapid hydrolysis of FPZ enanthate by BChE, HSA and CESs.

Effect of static tensile stress on enzymatic degradation of poly(glycerol sebacate).

Poly(glycerol sebacate) (PGS) is an excellent scaffold material in tissue engineering due to good biocompatibility and tunable mechanical properties. The degradation properties of PGS have been primarily explored in static phosphate buffer solution or enzyme solution. It is vital to understand how the tensile stress affect the degradation rate. In this study, PGS was synthetized by melt polycondensation and its properties were characterized. Then an in vitro degradation device which could provide different constant tensile stresses was carefully designed and established, and the enzymatic degradation of PGS was tested under 0-150 kPa at 37°C. It was found that holes of PGS surface arranged almost parallel to each other and perpendicular to the direction of tensile stresses at 100 kPa and 150 kPa after 2-4 days degradation. After 8 days degradation, the ultimate tensile strength (UTS) of PGS at 150 kPa was 0.28 MPa and the elastic modulus was 1.11 MPa, while the UTS of PGS was 0.44 MPa and the elastic modulus was 1.63 MPa before degradation, both of them have significant differences. Hence, the tensile stress and degradation time were proportional to the appear time and size of holes, leading to the decrease of mass loss, UTS and elastic modulus. The relationship between stress and PGS degradation rates was quantitatively described through our degradation experiments, providing guidance for suitable PGS applications in the future.

Beta-Hydroxybutyrate (BHB), Glucose, Insulin, Octanoate (C8), and Decanoate (C10) Responses to a Medium-Chain Triglyceride (MCT) Oil with and without Glucose: A Single-Center Study in Healthy Adults.

MCTs are increasingly being used to promote ketogenesis by patients on ketogenic diet therapy, but also by people with other conditions and by the general public for the perceived potential benefits. However, consumption of carbohydrates with MCTs and untoward gastrointestinal side effects, especially at higher doses, could decrease the sustainability of the ketogenic response. This single-center study investigated the impact of consuming carbohydrate as glucose with MCT oil compared to MCT alone on the BHB response. The effects of MCT oil versus MCT oil plus glucose on blood glucose, insulin response, levels of C8, C10, BHB, and cognitive function were determined, and side effects were monitored. A significant plasma BHB increase with a peak at 60 min was observed in 19 healthy participants (24.4 ± 3.9 years) after consuming MCT oil alone, and a more delayed but slightly higher peak was observed after consuming MCT oil plus glucose. A significant increase in blood glucose and insulin levels occurred only after MCT oil plus glucose intake. The overall mean plasma levels of C8 and C10 were higher with the intake of MCT oil alone. MCT oil plus glucose consumption showed improved scores for the arithmetic and vocabulary subtests.

The toxic effects of anabolic steroids "nandrolone decanoate" on cardiac and skeletal muscles with the potential ameliorative effects of silymarin and fenugreek seeds extract in adult male albino rats.

BACKGROUND: Anabolic steroids (AS) are commonly abused by body builders and athletes aiming to increase their strength and muscle mass but unfortunately, the long-term use of AS may lead to serious side effects. Nandrolone Decanoate is one of the Class II anabolic androgenic steroids which quickly spread globally and used clinically and illicitly. Our research was directed to assess the toxic effects of anabolic steroids on cardiac and skeletal muscles in male albino rats and to evaluate the potential ameliorative effects of fenugreek seeds extract and silymarin. METHODS: Our research was done on 120 male albino rats that were allocated into 6 groups; group I: Served as a control group, group II: Received the anabolic steroid Nandrolone Decanoate, group III: Received silymarin orally, group IV: Received fenugreek seeds extract orally, group (V): Received the anabolic steroid Nandrolone Decanoate and silymarin and group (VI): Received the anabolic steroid Nandrolone Decanoate and fenugreek seeds extract. By the end of the study, rats were sacrificed, and blood samples were collected for biochemical analysis and autopsy samples for histopathological examination. RESULTS: The anabolic steroids toxic effects on rats showed a significant decrease in serum High Density Lipoprotein (HDL) level and increase in cholesterol, triglycerides, and Low-Density Lipoprotein (LDL) levels. There was a significant elevation in cardiac troponin I level. As regards to histopathological examination of the cardiac and skeletal muscles, the study showed marked degenerative changes and necrosis. Both silymarin and fenugreek seeds extract provided a protective effect on the biochemical and histopathological changes. The antioxidant effects of silymarin and fenugreek seeds extract were evaluated on the heart, skeletal muscles and showed that, the tissue levels of Superoxide dismutase (SOD), Catalase and reduced glutathione (GSH) decreased in AS treated rats compared to the control group. On the other hand, the tissue Malondialdehyde (MDA) levels were elevated. CONCLUSIONS: Anabolic steroids have a toxic effect on the cardiac and skeletal muscles of albino rats with improvement by treatment with fenugreek seeds extract and silymarin.

Clarification of the Mechanism of Inhibiting the Maillard Reaction between Phosphatidylethanolamine and Sugars by Adding Fatty Acid Calcium Salts.

Lecithin is known to undergo heat induced deterioration by the Maillard reaction between 1 mol of any sugar, except 2-deoxy sugar, and 2 mol of phosphatidylethanolamine (PE). However, we have previously reported that adding fatty acid metal salts can inhibit heat deterioration of soybean lecithin (SL). To clarify the mechanism of inhibition, 1,2-di-O-stearoyl-sn-glycero-3-phosphatidylethanolamine (DSPE), d-glucose, and calcium stearate or calcium decanoate were heated in octane. When DSPE and d-glucose with calcium stearate or calcium decanoate were heated in the octane, the heat deterioration of DSPE was significantly inhibited, and no increase in UV absorption at 350 nm was observed. From these reactant solutions, one compound having a phosphate group and no primary amine was isolated, and NMR spectra confirmed that two molar of stearic acid derived from DSPE were coordinated to the amino group and phosphate group of DSPE. Therefore, we concluded that adding fatty acid metal salts reduced the nucleophilic reactivity of the amino group of PE and inhibited the Maillard reaction with sugars because two molar of fatty acid derived from PE coordinated to the amino group and phosphate group of PE.

Innovative Detection of Testosterone Esters in Camel Hair: Unravelling the Mysteries of Dromedary Endocrinology.

Introduction: Doping and steroid use represent a serious threat to animal health and can even lead to their untimely and painful death. However, doping is an acute problem in today's animal racing world, particularly in camel racing. Testosterone and its ten esters (benzoate, valerate, isocaproate, hexahydrobenzoate, decanoate, undecanoate, laurate, enanthate, cypionate, and caproate) are of utmost importance, because when they are administered to animals it is difficult to measure them efficiently. The levels of testosterone and its esters in camels and other animals are typically determined using urine and blood tests. The aim of this study was to develop and validate a liquid chromatographic-mass spectrometric (LC-MS/MS) method to determine testosterone esters in camel hair, and to apply the validated method to determine testosterone esters in collected samples. To our knowledge, this is the first report of such research. Results and Discussion: The levels of testosterone and its ten derivatives, along with the cortisol-D4 internal standard, were optimised for LC-MS/MS analysis; however, only testosterone along with its seven esters (namely benzoate, valerate, isocaproate, hexahydrobenzoate, decanoate, undecanoate and laurate) could be validated in camel hair. Only five testosterone esters could be determined in camel hair samples; the concentrations were obtained as 10.5-14.9 pg/mg for valerate (in three camels), 12.5-151.6 pg/mg for hexahydrobenzoate (in six camels), 4.8-32.1 pg/mg for laurate (in five camels), 5.1 pg/mg decanoate (in one camel), and 8.35-169 pg/mg for testosterone (in all 24 camels). Interestingly, the three racing camels displayed high concentrations of testosterone (59.2-169 pg/mg, all three camels), laurate (4.8-14.5 pg/mg, two camels), hexahydrobenzoate (116 pg/mg, one camel), decanoate (5.1 pg/mg, one camel), and valerate (11.7 pg/mg, one camel). Methods: Camel hair samples were collected from 21 non-racing dromedary camels along with three racing camels in Al Ain, UAE; these were decontaminated, pulverised, sonicated, and extracted prior to analysis. An LC-MS/MS method was employed to determine the levels of testosterone esters in the hair samples. Conclusions: This novel camel-hair test procedure is accurate, sensitive, rapid, and robust. The findings reported in this study could be significant to evaluate racing camels for suspected doping offenses. Further controlled testosterone supplementation studies are required to evaluate individual esters' effects on camel health and diseases and on performance enhancement levels. This new hair test could promote further studies in doping control, toxicology, and pharmacology, as well as having other clinical applications relating to camel health, injury, and disease.

Enhanced Bioactivity of Tailor-Made Glycolipid Enriched Manuka Honey.

Glycolipids can be synthetized in deep eutectic solvents (DESs) as they possess low water content allowing a reversed lipase activity and thus enables ester formation. Based on this principle, honey can also serve as a media for glycolipid synthesis. Indeed, this supersaturated sugar solution is comparable in terms of physicochemical properties to the sugar-based DESs. Honey-based products being commercially available for therapeutic applications, it appears interesting to enhance its bioactivity. In the current work, we investigate if enriching medical grade honey with in situ enzymatically-synthetized glycolipids can improve the antimicrobial property of the mixture. The tested mixtures are composed of Manuka honey that is enriched with octanoate, decanoate, laurate, and myristate sugar esters, respectively dubbed GOH, GDH, GLH, and GMH. To characterize the bioactivity of those mixtures, first a qualitative screening using an agar well diffusion assay has been performed with methicillin-resistant Staphylococcus aureus, Bacillus subtilis, Candida bombicola, Escherichia coli, and Pseudomonas putida which confirmed considerably enhanced susceptibility of these micro-organisms to the different glycolipid enriched honey mixtures. Then, a designed biosensor E. coli strain that displays a stress reporter system consisting of three stress-specific inducible, red, green, and blue fluorescent proteins which respectively translate to physiological stress, genotoxicity, and cytotoxicity was used. Bioactivity was, therefore, characterized, and a six-fold enhancement of the physiological stress that was caused by GOH compared to regular Manuka honey at a 1.6% (v/v) concentration was observed. An antibacterial agar well diffusion assay with E. coli was performed as well and demonstrated an improved inhibitory potential with GOH upon 20% (v/v) concentration.

Antibacterial Conductive UV-Blocking Adhesion Hydrogel Dressing with Mild On-Demand Removability Accelerated Drug-Resistant Bacteria-Infected Wound Healing.

The on-demand replacement of multifunctional hydrogel wound dressings helps to avoid bacterial colonization, and the on-demand painless peeling of tissue adhesive hydrogels on the wound site remains a major challenge to be solved. In this work, we design and develop a series of multifunctional dynamic Schiff base network hydrogels composed of cystamine-modified hyaluronic acid, benzaldehyde-functionalized poly(ethylene glycol)-co-poly(glycerol sebacate), and polydopamine@polypyrrole nanocomposite (PDA@PPy) with mild on-demand removability to enhance drug-resistant bacteria-infected wound healing. These hydrogels exhibited ideal injectable and self-healing properties, excellent tissue adhesion, in vivo hemostasis, good antioxidation, and conductivity. PDA@PPy inspired by melanin endows hydrogels with excellent antioxidant capacity, UV-blocking ability, and photothermal anti-infection ability. Based on the dynamic oxidation-reduction response of disulfide bonds inspired by the dissociation of the tertiary spatial structure transformation of poly-polypeptide chains, these hydrogels can achieve rapid painless on-demand removal under mild conditions by adding dithiothreitol. These multifunctional hydrogels significantly promoted collagen deposition and angiogenesis in the MRSA-infected full-thickness skin repair experiment. All the results showed that these multifunctional hydrogels with painless on-demand removal property showed great potential in clinical treatment of infected wounds.

Lipid nanoparticle-mediated lymph node-targeting delivery of mRNA cancer vaccine elicits robust CD8+ T cell response.

The targeted delivery of messenger RNA (mRNA) to desired organs remains a great challenge for in vivo applications of mRNA technology. For mRNA vaccines, the targeted delivery to the lymph node (LN) is predicted to reduce side effects and increase the immune response. In this study, we explored an endogenously LN-targeting lipid nanoparticle (LNP) without the modification of any active targeting ligands for developing an mRNA cancer vaccine. The LNP named 113-O12B showed increased and specific expression in the LN compared with LNP formulated with ALC-0315, a synthetic lipid used in the COVID-19 vaccine Comirnaty. The targeted delivery of mRNA to the LN increased the CD8+ T cell response to the encoded full-length ovalbumin (OVA) model antigen. As a result, the protective and therapeutic effect of the OVA-encoding mRNA vaccine on the OVA-antigen-bearing B16F10 melanoma model was also improved. Moreover, 113-O12B encapsulated with TRP-2 peptide (TRP2180-188)-encoding mRNA also exhibited excellent tumor inhibition, with the complete response of 40% in the regular B16F10 tumor model when combined with anti-programmed death-1 (PD-1) therapy, revealing broad application of 113-O12B from protein to peptide antigens. All the treated mice showed long-term immune memory, hindering the occurrence of tumor metastatic nodules in the lung in the rechallenging experiments that followed. The enhanced antitumor efficacy of the LN-targeting LNP system shows great potential as a universal platform for the next generation of mRNA vaccines.

Unveiling the mono-rhamnolipid and di-rhamnolipid mechanisms of action upon plasma membrane models.

Rhamnolipids (RLs) are biosurfactants with significant tensioactive and emulsifying properties. They are mainly composed by mono-RL and di-RL components. Although there are numerous studies concerning their molecular properties, information is scarce regarding the mechanisms by which each of the two components interacts with cell membranes. Herein, we performed phase-contrast and fluorescence microscopy experiments on plasma membrane models represented by giant-unilamellar-vesicles (GUVs) composed of 1,2-dioleoyl-sn-glycero-3-phosphocholine (DOPC), 2-[[(E,2S,3R)-1,3-dihydroxy-2-(octadecanoylamino) octadec-4-enyl]peroxy-hydroxyphosphoryl]oxyethyl-trimethylazanium (sphingomyelin, SM) and (3ß)-cholest-5-en-3-ol (cholesterol, CHOL) (1:1:1 M ratio), which present liquid-order (Lo) liquid-disorder (Ld) phase coexistence, in the presence of either mono-RL or di-RL in 0.06-0.25 mM concentration range. A new method has been developed to determine area and volume of GUVs with asymmetrical shape and a kinetic model describing GUV-RL interaction in terms of two mechanisms, RL-insertion and pore formation, has been worked out. Results show that the insertion of mono-RL in the membrane outer leaflet is the dominant process with no pore formation and a negligible effect in modifying membrane permeability, but induces lipid mixing. Conversely, the di-RL-GUV interaction begins with the insertion mechanism and, as the time passes by, the pore formation process occurs. The analyses of di-RL show that the whole process is only relevant in the Ld phase with a higher extent to 0.25 mM than to 0.06 mM.

A Route to Lipid ALC-0315: a Key Component of a COVID-19 mRNA Vaccine.

This paper describes a synthesis of ALC-0315 by a sequence that more than doubles the overall yield relative to the published one, and that employs much cleaner reactions, thereby facilitating purifications to a considerable extent.

Comparison of DLin-MC3-DMA and ALC-0315 for siRNA Delivery to Hepatocytes and Hepatic Stellate Cells.

Ionizable cationic lipids are essential for efficient in vivo delivery of RNA by lipid nanoparticles (LNPs). DLin-MC3-DMA (MC3), ALC-0315, and SM-102 are the only ionizable cationic lipids currently clinically approved for RNA therapies. ALC-0315 and SM-102 are structurally similar lipids used in SARS-CoV-2 mRNA vaccines, while MC3 is used in siRNA therapy to knock down transthyretin in hepatocytes. Hepatocytes and hepatic stellate cells (HSCs) are particularly attractive targets for RNA therapy because they synthesize many plasma proteins, including those that influence blood coagulation. While LNPs preferentially accumulate in the liver, evaluating the ability of different ionizable cationic lipids to deliver RNA cargo into distinct cell populations is important for designing RNA-LNP therapies with minimal hepatotoxicity. Here, we directly compared LNPs containing either ALC-0315 or MC3 to knock-down coagulation factor VII (FVII) in hepatocytes and ADAMTS13 in HSCs. At a dose of 1 mg/kg siRNA in mice, LNPs with ALC-0315 achieved a 2- and 10-fold greater knockdown of FVII and ADAMTS13, respectively, compared to LNPs with MC3. At a high dose (5 mg/kg), ALC-0315 LNPs increased markers of liver toxicity (ALT and bile acids), while the same dose of MC3 LNPs did not. These results demonstrate that ALC-0315 LNPs achieves potent siRNA-mediated knockdown of target proteins in hepatocytes and HSCs, in mice, though markers of liver toxicity can be observed after a high dose. This study provides an initial comparison that may inform the development of ionizable cationic LNP therapeutics with maximal efficacy and limited toxicity.

Optimization of Lipid Nanoparticles for saRNA Expression and Cellular Activation Using a Design-of-Experiment Approach.

Lipid nanoparticles (LNPs) are the leading technology for RNA delivery, given the success of the Pfizer/BioNTech and Moderna COVID-19 mRNA (mRNA) vaccines, and small interfering RNA (siRNA) therapies (patisiran). However, optimization of LNP process parameters and compositions for larger RNA payloads such as self-amplifying RNA (saRNA), which can have complex secondary structures, have not been carried out. Furthermore, the interactions between process parameters, critical quality attributes (CQAs), and function, such as protein expression and cellular activation, are not well understood. Here, we used two iterations of design of experiments (DoE) (definitive screening design and Box-Behnken design) to optimize saRNA formulations using the leading, FDA-approved ionizable lipids (MC3, ALC-0315, and SM-102). We observed that PEG is required to preserve the CQAs and that saRNA is more challenging to encapsulate and preserve than mRNA. We identified three formulations to minimize cellular activation, maximize cellular activation, or meet a CQA profile while maximizing protein expression. The significant parameters and design of the response surface modeling and multiple response optimization may be useful for designing formulations for a range of applications, such as vaccines or protein replacement therapies, for larger RNA cargoes.

Lipase-Catalyzed Poly(glycerol-1,8-octanediol-sebacate): Biomaterial Engineering by Combining Compositional and Crosslinking Variables.

This study examined poly(glycerol-1,8-octanediol-sebacate) (PGOS) copolymers with low-level substitution of O (1,8-octanediol) for G (glycerol) units (G/O ratios 0.5:0.5, 0.66:0.33, 0.75:0.25, 0.8:0.2, and 0.91:0.09) prepared in bulk by immobilized Candida antarctica Lipase B (N435) catalysis. The central question explored was the extent that exchanging less than half of poly(glycerol sebacate) (PGS) glycerol units with 1,8-octanediol can be used as a strategy to fine-tune biomaterial properties. Synthesized copolymers having G/O ratios of 0.66:0.33, 0.75:0.25, 0.8:0.2, and 0.91:0.09 have similar molecular weights, where Mw varied from 52,800 to 63,800 g/mol, Mn varied from 5100 to 6450 g/mol, and DM (molecular mass dispersity, Mw/Mn) values were also similar (8.4-11.4). All of the copolymers were branched, and dendritic glycerol units reached 11% for PGOS-0.91:0.09:1.0. Analysis of DSC second heating scans revealed that copolymers with higher 1,8-octanediol contents have relatively higher Tm and ΔHf values. Over the copolymer compositional range studied herein, Tm and ΔHf values varied from 5.3 to 21.1 °C and 8.0 to 23.1 J/g, respectively. Stress-strain curves of PGOS copolymers cured at 140 °C for 48 h exhibited either a unimodal, bimodal, or trimodal response to tensile loading. Varying G/O from 10:1 to 2:1 resulted in significant increases in the peak stress (0.26-4.01 MPa), preyield modulus (0.65-62.59 MPa), failure to strain (64-110%), and failure toughness (0.1-0.56 MPa). This demonstrates that altering the G/O ratio over a narrow compositional range provides biomaterials with widely different yet tunable mechanical properties. Further investigation of PGOS-0.75:0.25:1.0 films revealed that varying the cure conditions from 120 to 160 °C for periods of 24-72 h provides access to biomaterials with a failure strain range from 15 to 224% and Young's modulus from 1.17 to 10.85 MPa. Hence, using the dual variables of compositional variation and changes in cure conditions provides an exciting platform for PGS analogues to optimize material-tissue interactions. Increased contents of 1,8-octanediol slowed in vitro degradation. Slowed degradation of PGOS relative to PGS will be valuable for use in slower healing wounds.